Specifications      Operation      Troubleshooting

Specifications:

The Next Rocker works all over the world.

The rocker uses 24V DC supplied by a small external power supply that plugs into a wall outlet.  Next Advance will supply the appropriate power supply for the local power and wall outlet configuration.

The maximum load.

The rocker can handle 11 lbs. (5 kg).

The range for the tilt angle.

The amount that the rocker platform tilts back and forth can be adjusted from as little as +/- 1 degree to as much as +/- 18 degrees.

The rocking rate

The rocking rate can be as slow as barely moving to a maximum speed of 80 cycles per minute (160 rocking motions per minute).  Alternative versions are available with slower, more powerful motors.  See the next FAQ.

Slow and Super Slow versions

The Next Rockers come in standard, slow, and super slow versions.  The standard version can rock at speeds up to about 80 cycles per minute.  For those many applications that require slow, smooth rocking, we recommend the slow ( up to about 20 cycles per minute) or super slow (up to about 5 cycles per minute) versions.  They provide much finer speed control at the lower speeds.  There is an additional cost of $100 for these versions.  The motor in these versions is geared down for slower operation and greater power, just as gears on a bicycle allow for more power at lower speeds.  We highly recommend these versions, because of the additional power, for the extra large platform rocker, Next Rocker XL, and for the Stack-3 and Stack-4 Rockers.

Use in incubators/cold rooms

The Next Rocker can operate in incubators (up to 60C) or cold rooms (down to 4C) if the temperature is kept constant and the humidity is not excessive.  Temperature swings which cause condensation will damage the electronics and void the warranty.   In fact, the electronic circuitry includes additional heat sinks to ensure reliable operation at elevated temperatures.

What if the motor burns out?

Will the motor burn out?  Yes, after years of use.  If it does, we will refurbish the unit and replace the motor for $200 plus shipping. 

Warranty

The NEXT ROCKER comes with a 30 day money back guarantee and a 2 year warranty.  Accidents or condensation void the warranty.  Next Advance is not liable for any consequential damages.

Back to Top

Operation:

Adjusting the tilt angle. 

To adjust the angle, use a flat blade screwdriver to loosen the labeled screw on the rear of the instrument, slide the linkage to the desired position, then tighten the screw.

Adjusting the rocking rate. 

You can turn the knob on the front of the instrument to adjust the rocking speed.

Cleaning the rubber mat. 

You can remove the rubber mat from the platform and clean it with soap water.  Let it dry before placing it back on the platform.

Back to Top

Troubleshooting

If nothing happens, check that the rocker is plugged in and that power switch on the front of the instrument is turned on.

If the unit stops working, turn the system off for 15 minutes to allow the electronics to reset.  If the Next Rocker does not turn on after this period, contact customer service. 

 Back to Top